When will I ever learn? (SB-101)

[Kenth B Astrom]

Hello Gang,

Many thanks for all the overwhelmingly helpful tips and tricks on this
matter from all of you!


Yes, after cleaning the unit with contact cleaner, I carefully observed the
regulator tube OA2 (V18) when I fired it up again.  

Noticing that this VR tube was not lit in any way, I switched it out for one
I had in a Drake TR4C, which I know works, and it still did not light up.

In doing this though I noticed that the R305 (2500 ohm, 7W) next to the
regulator tube V18, was getting EXTREMELY hot.

It also seem to have been 'upgraded' at some point to a 10W resistor,
instead of the original 7W.

Again guys, thanks for all the help - now I have something firm to go by and
also and thanks to Tom K3TVC also an electronic copy of the manual!

I'll keep digging!

Thanks a bunch!

Best Regards
Kenth Astrom / W1JKP


-----Original Message-----
From: Heathkit Owners and Collectors List [mailto:HEATH at LISTS.TEMPE.GOV] On
Behalf Of Kenneth G. Gordon
Sent: Monday, March 08, 2010 1:29 PM
To: HEATH at LISTS.TEMPE.GOV
Subject: Re: When will I ever learn? (SB-101)

Bob Burns G3OOU brought up an excellent point: is the VR tube lit?

I have had more than one of my HW/SB all-banders in which either one or both
of the larger resistors near the back right hand side, near the audio output
tube, were open, or had become unsoldered from the circuit board due to
their heat. I always replace those two resistors with higher-wattage units,
and mount them so that their heat does not so badly effect the circuit
board.

If the seller says that it worked before he shipped it, then perhaps
something "joggled loose" during shipping, which is NOT at all uncommon.

Check to see if the VR tube is lit. If it is NOT lit, then the receiver will
NOT work.

Ken Gordon W7EKB

-----------------------------------------------------------
Products bought, sold or traded here is the responsibility of the parties
involved.  This list and the City of Tempe are not responsible for losses or
misrepresentations of any kind.  Buyer beware!

-----------------------------------------------------------
This list is a public service of the City of Tempe, Arizona
-----------------------------------------------------------

Subscription control - http://www.tempe.gov/lists/control.aspx?list=HEATH
To post - HEATH at LISTS.TEMPE.GOV
Archives - http://lists.tempe.gov/archives/HEATH.html

-----------------------------------------------------------
Products bought, sold or traded here is the responsibility of the
parties involved.  This list and the City of Tempe are not responsible
for losses or misrepresentations of any kind.  Buyer beware!

-----------------------------------------------------------
This list is a public service of the City of Tempe, Arizona
-----------------------------------------------------------

Subscription control - http://www.tempe.gov/lists/control.aspx?list=HEATH
To post - HEATH at LISTS.TEMPE.GOV
Archives - http://lists.tempe.gov/archives/HEATH.html